PEI/APP改性脲醛树脂制备阻燃胶合板及性能

以聚乙烯亚胺(PEI)为改性剂处理聚磷酸铵(APP)制备得到APP@PEI阻燃体系,并将其加入到脲醛树脂(UF)中,制备阻燃胶合板。研究了APP@PEI对UF胶黏剂理化性能的影响,并进一步探讨其对胶合性能及阻燃性能的影响。结果表明:APP、PEI和APP@PEI对UF的黏度、pH和固化时间均有影响。当APP添加量为10%时,UF的黏度由3.843 Pa·s上升至8.270 Pa·s,pH降至5.67,固化时间由91 s降至87 s;当PEI添加量为0.91%时,由于UF体系中支化和交联程度增加,黏度上升至41.433 Pa·s,pH和固化时间分别提升至9.91和116.3 s;而APP@PEI能降低对UF各项性能的影响,添加10%APP@PEI时UF的黏度、pH和固化时间分别为5.966 Pa·s、6.33和94.3 s。添加APP后,胶合板的胶合强度均低于Ⅱ类胶合板强度标准(0.7 MPa);添加PEI后,胶合板的胶合强度能够提升18%以上;APP@PEI添加量为10%时,胶合板的胶合强度达0.85 MPa,高于Ⅱ类胶合板强度标准要求。添加APP、PEI和APP@PEI对胶合板的阻燃性能有不同影响,单独添加PEI无法改善胶合板的阻燃性能,当APP和APP@PEI添加量为10%,15%和20%时,胶合板的极限氧指数(LOI)分别比未添加阻燃剂时提高0.8%,2.0%,2.5%和1.2%,2.2%,3.1%。     

Application of urease inhibitor improves protein composition and bread‐baking quality of urea fertilized winter wheat

Background: Nitrogen losses is an economic problem for wheat production and a high risk to the environment. Therefore, improved N fertilizer management is a key to increasing the N efficiency and minimizing N losses. To increase N efficiency, enhanced fertilizers such as urea combined with urease inhibitor can be used. Aims: The aim of present study was to evaluate the effects of different N forms on grain storage protein subunits in winter wheat and to examine whether the observed changes correlate with parameters of baking quality. Methods: The investigation was performed over two consecutive years at two locations in Germany. Protein subunits were analyzed by SDS‐PAGE. Results: Protein concentrations were similarly increased after fertilization with ammonium nitrate and urea + urease inhibitor. Analysis of the individual storage protein fractions indicated that both fertilizers specifically enhanced ω‐gliadins and HMW glutenins, but the effect was more pronounced in the ammonium nitrate treatment. Application of urea + urease inhibitor had greater influence on the protein composition and resulted in higher specific baking volume as well as the best fresh keeping ability, in comparison with urea treatment. Conclusion: Considering that the urea + urease inhibitor treatment resulted in almost comparable improvements of NUE and baking quality, with the additional benefit of reduced N losses in combination with easy handling, urea + urease inhibitor can be recommended as a viable alternative to both urea alone and ammonium nitrate treatments. This opens up an opportunity for the reduction of N loss in wheat production when use of urea is preferred.     

改性尿素硝酸铵溶液调控氮素挥发和淋溶的研究

为了提高肥料的利用率,以尿素硝酸铵溶液为原料、聚氨酸为保护剂,复合抑制剂NBPT(N-丁基硫代磷酰三胺)和DMPP(3,4-二甲基吡唑磷酸盐)为材料,开发出改性尿素硝酸铵溶液(YUL1和YUL2),研究其对华北平原夏玉米追肥过程中的氨挥发和淋溶损失的调控效果。田间试验设置6个处理:不施氮肥(CK)、农民习惯追施尿素(CN)、优化追施尿素(CNU)、优化追施尿素硝酸铵溶液(UAN)、优化追施改性尿素硝酸铵溶液(YUL1)和优化追施改性尿素硝酸铵溶液(YUL2)。采用扫描电镜和能谱仪分析相关指标变化,在夏玉米喇叭口期追施氮肥后15d内进行田间原位连续动态观测氨挥发和土壤铵态氮和硝态氮变化,并在玉米成熟期测定产量,计算经济效益。结果表明,改性尿素硝酸铵溶液清澈无杂质,流延后成膜表面光滑、致密,抑制剂在膜表面分布均匀;能谱测试膜层表面磷硫含量增高,证明复合抑制剂与尿素硝酸铵溶液达到有效融合。在同等优化施氮量下:与CNU相比, YUL1氨挥发总量显著降低19.3%, YUL2增加9.6%;与UAN相比, YUL1、YUL2分别显著降低57.3%和42.0%。与其他施氮处理相比, YUL1和YUL2夏玉米季生长中后期0～20 cm土层依然保持相对较高的氮素含量水平,夏玉米收获后土壤硝态氮含量分别比CNU高46.0%和43.4%,比UAN高45.6%和44.7%;180～200cm土层硝态氮含量显著低于其他处理。在保证产量和净收益的同时,改性尿素硝酸铵肥料显著降低了氮素的氨挥发和淋溶损失浓度,尿酶抑制剂含量相对较高的YUL1抑制氨挥发的效果更好,硝化抑制剂含量相对高的YUL2硝态氮向下淋失的风险更小。     

磷酸铵镁堆肥产品养分释放特性及其肥效研究

为了研究磷酸铵镁堆肥产品的氮磷养分释放特性及其肥效,分别采用土柱淋溶方法及盆栽试验研究了磷酸铵镁堆肥(MAPC)产品的氮磷养分释放特性及对油菜的肥效,并与普通化肥(CCH)、普通堆肥(CCO)、磷酸铵镁肥(MAP)3种肥料进行对比。结果表明:在整个淋溶过程中,CCH和MAPC处理淋溶液的总氮及总磷浓度均较其他处理高;MAP肥具有缓释性,且堆肥对其养分释放具有促进作用;CCO处理的养分释放最慢。在最后一次淋洗(即第5次)后,总氮及总磷养分浓度排序均为:CCHMAPCMAPCCO。盆栽试验18 d后油菜快速生长,且与对照(不施肥)处理相比,MAP和MAPC处理能显著提高油菜的株高及生物量。在45 d盆栽试验结束时,CCH、CCO、MAP和MAPC处理的生物量分别是对照处理的14.8、4.8、20.5倍和16.0倍。MAP处理能显著提高油菜的养分含量,TN和TP含量分别比对照提高了2.24 g·kg~(-1)和1.54 g·kg~(-1)。研究表明,4种肥料均可改善油菜的生长发育情况,且MAP和MAPC的肥效优于CCH和CCO,在堆肥中利用鸟粪石结晶原理可固定部分氮磷元素,提高堆肥产品肥效。     

硝酸钠和乙酸铵配施对黄果柑幼苗光合特性的影响

利用Li–6400便携式光合测定系统，测定了硝酸钠与乙酸铵11个不同配比处理的黄果柑幼苗在不同季节的光合能力。结果表明：1) 硝酸钠与乙酸铵配比处理黄果柑幼苗的光合能力均表现为夏季最强，冬季最弱，秋季强于春季；叶绿素a、叶绿素b和总叶绿素含量均表现为夏季最高，冬季最低，秋季高于春季。2) 硝酸钠和乙酸铵配比(质量比)为8∶2时，黄果柑幼苗叶片的净光合速率、蒸腾速率、水分利用率和气孔导度以及叶绿素a、叶绿素b和总叶绿素含量均高于其他处理，单施硝酸钠或乙酸铵处理都低。综合比较分析，硝酸钠和乙酸铵配比为8∶2时，黄果柑幼苗的光合能力最强。     

木耳菌渣稻苗基质化利用难点及解决技术

为有效转化利用废弃木耳菌渣,解决木耳菌渣稻苗基质化利用过程中出现的稻苗黄化现象问题,通过分析木耳菌渣理化性质及对水稻种子采取硫酸亚铁溶液浸种处理的方法,进行木耳菌渣稻苗基质化利用研究。结果表明:1)虽然腐熟菌渣的有机质含量、保水性及速效养分等特性有利于做水稻育苗基质,但盐分浓度较高、偏碱性、密度较小不适宜单一菌渣做育苗基质;2)单一菌渣基质培育稻苗,会出现黄化现象,原因在于单一菌渣基质有效铁含量偏低,造成了叶片含铁量少;3)硫酸亚铁浸种处理可以控制稻苗黄化现象,但会诱导植株株高伸长;4)0.014mol/L硫酸亚铁与0.051mmol/L多效唑混合浸种液在20℃下浸种处理3d,能够有效控制稻苗黄化现象和植株的徒长。同体积的腐熟菌渣和稻田土混合配制成的育苗基质,稻种采用硫酸亚铁溶液与多效唑溶液混合浸种处理的方法,能够育出壮实的大龄机插秧苗。     

Inhibiting fungus on largemouth bass eggs with copper sulfate and its toxicity to fry and juveniles

This study determined the effectiveness of copper sulfate (CuSO₄) to inhibit fungal growth (caused by Saprolegnia spp.) on largemouth bass (LMB) eggs spawned on/in fiber mats in very high-alkalinity/-hardness waters; experiments also determined the toxicity of CuSO₄ to LMB fry and juveniles. An untreated control and three CuSO₄ concentrations (10, 20, and 40 mg/L) were tested under a flow-through scenario in the effectiveness experiment. Eggs were treated daily until hatching began. Fungal load at the time of hatch had a total area > 3.0 cm² in the untreated controls, total area 1.0 to <2.0 cm² in the 10 and 20 mg/L CuSO₄ treatments, and total area > 1.0 cm² in the 40 mg/L CuSO₄ treatments. Fungus samples were identified as Saprolegnia australis. The 24-hr median lethal concentration (LC50) values on the LMB yolk-sac and swim-up fry were 32.0 and 4.6 mg/L CuSO₄, respectively; the No Observed Effect Concentrations (NOEC) were 16.0 and 0.125 mg/L CuSO₄, respectively. Juvenile LMB were extremely tolerant to CuSO₄, and their 24-hr LC50 value was 185.5 mg/L; the NOEC was 64 mg/L. This study indicates that CuSO₄ can be an important resource for hatcheries to control egg fungus, especially in high-alkalinity/-hardness waters.     

An improved method for extraction of sorghum polymeric protein complexes

A method for fractionating sorghum proteins using extraction solvents and techniques designed to obtain polymeric protein structures (especially disulfide linked) was developed. Extraction and separation conditions were optimized in terms of completeness of protein extraction, sample stability, and analytical resolution. After pre-extraction of albumins and globulins, a 3-step sequential procedure involving no reducing agents was applied to ground whole sorghum flour. The three fractions obtained represented proportionally different protein polymer contents and molecular weight distribution as evidenced by comparative size exclusion chromatography. Protein composition also varied among the extracts with differences in kafirin composition and non-kafirin proteins detected in the fractions by RP-HPLC and SDS-PAGE analysis. The ability to quantify and further characterize sorghum polymeric protein complexes will be useful for additional studies linking protein structures with functionality and digestibility and variations for these properties within diverse sorghum germplasm.     

阿维菌素等三种常规渔药对卡拉白鱼的急性毒性

采用半静态法,研究了三种常规渔药阿维菌素、三氯异氰脲酸和硫酸铜对卡拉白鱼(Chalcalburnus chal coides aralensis)急性毒性效应。结果表明:阿维菌素对卡拉白鱼24、48、72、96 h的半致死浓度分别为6.25、4.66、3.66和2.82 mg/L,安全浓度为0.77 mg/L;三氯异氰尿酸对卡拉白鱼24、48、72、96 h的半致死浓度分别为3.22、2.49、2.19、1.79 mg/L,安全浓度为0.45 mg/L;硫酸铜对卡拉白鱼24、48、72、96 h的半致死浓度分别为5.56、3.96、2.03、1.74 mg/L,安全浓度为0.6 mg/L。三种药物对卡拉白鱼毒性高低依次为:硫酸铜三氯异氯尿酸阿维菌素。三种常规渔药的安全浓度近于或高于生产中常用泼洒浓度,可放心使用。     

γ-戊内酯/水复合溶剂体系中金属硫酸盐催化半纤维素定向转化制备糠醛

以廉价金属硫酸盐为催化剂,在γ-戊内酯/水复合溶剂中催化半纤维素定向转化制备糠醛,糠醛得率高达50.2%,半纤维素液化转化率达95.5%。在γ-戊内酯/水复合溶剂中,以金属硫酸盐为催化剂进一步研究了直接催化木质纤维生物质原料玉米芯和竹粉定向转化制备糠醛,其中糠醛得率分别达39.5%、29.7%,木质纤维原料液化转化率分别达86.5%、80.5%。